中空玻璃生产线的使用寿命一般取决于中空玻璃生产线的清洗段和板压段，那么，如何保养好中空玻璃生产线的清洗段和板压段，就关系到整套中空玻璃设备的使用寿命，威力智能为您分享中空玻璃生产线的清洗段和板压段如何保养：
The service life of the insulating glass production line generally depends on the cleaning section and plate pressing section of the insulating glass production line. How to maintain the cleaning section and plate pressing section of the insulating glass production line is related to the service life of the whole set of insulating glass equipment. Power intelligence shares with you how to maintain the cleaning section and plate pressing section of the insulating glass production line:
中空玻璃生产线清洗干燥段
Cleaning and drying section of insulating glass production line
中空玻璃生产线清洗机现在大多数厂家用的是不锈钢，一般不会生锈,那重 点就是毛刷和电机的保养了，毛刷一般能用能长期使用，如果不脱 毛可以一直使用，只是他的下端轴承，因为湿度大容易生锈，造成毛刷锈住、抱死或阻力大等故障，还容易烧掉电机。威力智能提供的中空玻璃生产线的毛刷都是采用进口杜邦丝，清洗效果好， 不易脱 毛，可以长时间使用；而且去掉了海绵辊，既保证了玻璃不会二次污染，采用高压风机循环热风，保证吹干效果；再就是下端采用纯钢甚至纯铜轴承，大限度的隔绝生锈造成损失等情况的发生。

At present, most manufacturers of hollow glass production line cleaning machines use stainless steel, which generally will not rust. The key point is the maintenance of the brush and motor. The brush can generally be used for a long time. If it does not depilate, it can be used all the time, but its lower bearing is easy to rust due to high humidity, resulting in brush rust, locking or high resistance, and it is easy to burn the motor. The brushes of the insulating glass production line provided by Weili intelligence are imported DuPont silk, which has good cleaning effect, is not easy to depilate, and can be used for a long time; Moreover, the sponge roller is removed, which not only ensures that the glass will not be polluted again, but also adopts high-pressure fan to circulate hot air to ensure the drying effect; Then, pure steel or even pure copper bearings are used at the lower end to greatly isolate the loss caused by rust.

中空玻璃生产线板压段
Plate pressing section of insulating glass production line
再就是板压机，特别是中空玻璃生产线内合片的板压机有很多气缸和电磁阀，如果不注意保养、加油、排水，很容易卡阀或烧线圈，特别是吸盘上的电磁阀不可以在油水分离器里加油润滑，因为那样会造成吸盘上也有油，污染玻璃。所以只能拔下电磁阀的进气管用油壶加一点润滑油。
In addition, the plate press, especially the plate press in the insulating glass production line, has many cylinders and solenoid valves. If you do not pay attention to maintenance, refueling and drainage, it is easy to jam the valve or burn the coil. In particular, the solenoid valve on the suction cup can not be lubricated in the oil-water separator, because there will be oil on the suction cup and pollute the glass. Therefore, you can only unplug the intake pipe of the solenoid valve and add a little lubricating oil with an oil pot.
还有就是，丁基胶涂布机，也是需要注意保养的，在冷胶状态不能退缸，因为冷胶状态下胶和活塞是粘在一起的，如果强退，很容易把胶缸拔坏；再就是加胶时一定检查好胶块的外观有没有粘有铁销、小石块和铁钉等杂物，这些东西是很容易划伤胶缸或堵住胶头的。
In addition, the butyl rubber coater also needs attention to maintenance. The cylinder cannot be returned in the cold rubber state, because the rubber and the piston are stuck together in the cold rubber state. If it is forcibly returned, it is easy to pull out the rubber cylinder; In addition, when adding glue, be sure to check the appearance of the rubber block for sundries such as iron pins, small stones and nails, which are easy to scratch the rubber cylinder or block the rubber head.